Hubbell Electric Heater Company CE110 User Manual

OPERATING AND MAINTENANCE MANUAL FOR COMMERCIAL ELECTRIC WATER HEATER ELECTRIC HEATER COMPANY BASE MODEL

10 ELECTRICAL INSTALLATION 1. Enter the electrical service entrance with properly sized feeder leads, conforming to the voltage stamped on the rati

11Ground L1 L2 High Limit Cutout

12 INSTALLATION WITHOUT TEMPERING VALVE Piping to Hot Water Support Bracket – (bottom bracket not shown)

13INSTALLATION WITH TEMPERING VALVE Tempering ValvePiping to Hot Water Support Bracket – (bottom bracket not shown) Air Gap Floor DrainRelief Valv

14 SECTION III - SCHEDULED MAINTENANCE AND OPERATION WARNING / CAUTION Before performing any maintenance procedure, make certain power supply is O

15 ANNUAL INSPECTION 1. Flush tank as follows a. Shut off power supply. b. Attach a hose to the drain valve installed in the cold water piping.

16 SECTION IV – TROUBLESHOOTING Symptom Probable Cause Corrective Action / Remedy Circuit breaker tripped at source. Reset circuit breaker. High

17SECTION V - SERVICING & REPLACEMENT OF PARTS WARNING / CAUTION Before servicing or replacing any part make sure to turn the power supply s

18 HEATING ELEMENT 1. Disconnect power from unit. 2. Shut off incoming water supply. 3. Attach hose to drain connection. 4. Lift manual release

19THERMOSTAT 1. Disconnect power from unit. 2. Remove access cover and locate thermostat. 3. Disconnect the two (2) control wires.

2 HUBBELL ELECTRIC HEATER COMPANY P.O.BOX 288 STRATFORD, CT 06615 PHONE: (203) 378-2659 FAX: (203) 378-3593 INTERNET: http://www.hubbell

20 RELIEF VALVE 1. Disconnect power from unit. 2. Shut off incoming water supply. 3. Lift test lever on relief valve to relieve pressure in tank.

21SECTION VI – WARRANTY LIMITED WARRANTY AND TANK REPLACEMENT POLICY The Electric Heater Co., (hereinafter called, the "Company"), offer

22 CONDITION AND LIMITATIONS Limited Warranty and tank Replacement Policy are valid only if you comply with the following conditions and limitations

3WARNING / CAUTION 1. Please read all instructions prior to installing water heater. 2. Tank is to be completely filled with water and all air is

4 TABLE OF CONTENTS SECTION TITLE PAGE #

5PARTS LOCATION DIAGRAMHigh Limit Access Cover Electrical Junction Box Cover Hot Water Outlet - (Cold water inlet not shown on bottom). High Limit

6 SECTION I - GENERAL INFORMATION GENERAL DESCRIPTION This book describes a packaged electric water heater that is a stationary, self-contained unit

7CONTROL THERMOSTAT The temperature of the water in the heater is regulated by the adjustable, automatic, immersion thermostat located behind the ja

8 SECTION II – INSTALLATION GUIDELINES WARNING / CAUTION DO NOT TURN ON THE ELECTRIC POWER SUPPLY to this equipment until heater is completely fil

9PIPING INSTALLATION NOTE: The most effective means for preventing deterioration from accelerated corrosion due to galvanic and stray current is